Red Hot® Concentrate Powder

MATERIAL SAFETY DATA SHEET

Date-Issued:	07/07/2000
MSDS Ref. No:	151CP
Date-Revised:	12/17/2003
Revision No:	1

Red Hot® Concentrate Powder

1. PRODUCT AND COMPANY IDENTIFICATION

PRODUCT NAME: Red Hot® Concentrate Powder

PRODUCT DESCRIPTION: Cleaner Concentrate Powder

PRODUCT CODE: 51-C-P

PRODUCT FORMULATION NAME: Red Hot® Concentrate Powder

MANUFACTURER	24 HR. EMERGENCY TELEPHONE NUMBERS


Auto Wax Company, Inc. Auto Magic® 1275 Round Table Drive Dallas, TX 75247 Product Stewardship: 1-214-631-4000 Transportation: 1-800-826-0828 Auto Wax Company, Inc. Auto Magic®	CHEMTREC (U.S.): CANUTEC: Emergency Phone:	(800) 424-9300 (613) 996-6666 1-800-826-0828

COMMENTS: To the best of our knowledge, this Material Safety Data Sheet conforms to the requirements of US OSHA 29 CFR 1910.1200.

2. COMPOSITION / INFORMATION ON INGREDIENTS

Chemical Name	Wt.%			CAS#		EINECS#
Disodium Metasilicate (sodium metasilicate)		60 - 80		6834-92-0		229-912-9

COMMENTS: Product composition ranges shown are typical values for health, safety and environmental use and are not intended as specification.

3. HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW

IMMEDIATE CONCERNS: Corrosive to eyes and skin. High pH of this material makes it harmful to aquatic life.

POTENTIAL HEALTH EFFECTS

EYES: Can cause chemical burn.

SKIN: Causes skin burns.

INGESTION: Can burn mouth, throat and stomach.

INHALATION: Prolonged or excessive inhalation may cause respiratory tract irritation.

SIGNS AND SYMPTOMS OF OVEREXPOSURE

EYES: Eye contact may cause burns, irritation, tearing and corneal damage.

SKIN: Skin contact may cause severe burns.

INGESTION: Ingestion may cause nausea and irritation.

CHRONIC: not available

MEDICAL CONDITIONS AGGRAVATED: dermititis may be aggravated by excessive exposure to skin.

ROUTES OF ENTRY: include skin contact, eye contact and ingestion

TARGET ORGAN STATEMENT: not available

SENSITIZATION: not available

HEALTH HAZARDS: Moderately irritating to the eyes.

4. FIRST AID MEASURES

EYES: Flush eye with water for 15 minutes. Get medical attention.

SKIN: Wash with soap and water. Get medical attention if irritation develops or persists.

INGESTION: Get medical attention immediately.

INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention.

5. FIRE FIGHTING MEASURES

FLASHPOINT AND METHOD: none

AUTOIGNITION TEMPERATURE: none

FLAMMABLE CLASS: Material will not burn.

EXTINGUISHING MEDIA: use water, foam, dry chemical or cabon dioxide extinguisher

EXPLOSION HAZARDS: none

AUTOIGNITION TEMPERATURE: none

6. ACCIDENTAL RELEASE MEASURES

SMALL SPILL: Vacuum or sweep up material and place in a disposal container.

ENVIRONMENTAL PRECAUTIONS

WATER SPILL: Avoid runoff into storm sewers and ditches which lead to waterways.

7. HANDLING AND STORAGE

GENERAL PROCEDURES: Keep out of reach of Children.

STORAGE: Store in a dry area.

SHELF LIFE: one year

8. EXPOSURE CONTROLS / PERSONAL PROTECTION

EXPOSURE GUIDELINES:

OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200)

	EXPOSURE LIMITS
	OSHA PEL		ACGIH TLV		Supplier OEL
	ppm	mg/m³	ppm	mg/m³	ppm	mg/m³
Disodium Metasilicate (sodium metasilicate)

ENGINEERING CONTROLS: Good general ventilation should be sufficient to control airborne levels.

PERSONAL PROTECTIVE EQUIPMENT

EYES AND FACE: Wear safety glasses with side shields or goggles.

SKIN: Use Nitrile/ Vinyl gloves

RESPIRATORY: NIOSH respirator - in absence of proper environmental controls.

PROTECTIVE CLOTHING: Clean, body-covering clothing

9. PHYSICAL AND CHEMICAL PROPERTIES

PHYSICAL STATE: Solid

ODOR: Typical

APPEARANCE: Red Granular Powder

pH: >11 ( 5% solution )

PERCENT VOLATILE: 0

SOLUBILITY IN WATER: 100 %

SPECIFIC GRAVITY: Not Available

10. STABILITY AND REACTIVITY

STABLE: YES

HAZARDOUS POLYMERIZATION: NO

CONDITIONS TO AVOID: None.

11. TOXICOLOGICAL INFORMATION

SENSITIZATION: not available

TARGET ORGANS: not available

SUBCHRONIC:

not available

CARCINOGENICITY:

IARC: Listed by IARC- NO

NTP: Listed by NTP- NO

OSHA: Listed by OSHA- NO

REPRODUCTIVE EFFECTS: not available

NEUROTOXICITY: not available

12. ECOLOGICAL INFORMATION

ENVIRONMENTAL DATA: not available

ECOTOXICOLOGICAL INFORMATION: not available

13. DISPOSAL CONSIDERATIONS

DISPOSAL METHOD: Dispose in accordance with local, state, and federal laws.

14. TRANSPORT INFORMATION

DOT (DEPARTMENT OF TRANSPORTATION)

PROPER SHIPPING NAME: Disodium Trioxosilicate

PRIMARY HAZARD CLASS/DIVISION: 8

UN/NA NUMBER: 3253

PACKING GROUP: III

15. REGULATORY INFORMATION

CANADA

WHMIS HAZARD SYMBOL AND CLASSIFICATION

WHMIS Corrosive

WHMIS Toxic

16. OTHER INFORMATION

PREPARED BY: Tony Casmus

REVISION SUMMARY Revision #: 1

This MSDS replaces the February 22, 2001 MSDS. Any changes in information are as follows:
In Section 3
Emergency Overview - Immediate Concerns Potential Heath Effects - Eyes Potential Health Effects - Skin Potential Health Effects - Ingestion Signs & Symptoms - Eyes Signs & Symptoms - Skin

In Section 4
Firstaid - Eyes Firstaid - Skin

In Section 14
DOT Proper Shipping Name DOT Primary Hazard Class/Division DOT UN/NA Number DOT Packing Group Other DOT Shipping Information

In Section 16
HMIS Flammability HMIS Health HMIS Reactivity NFPA Health NFPA Reactivity HMIS Health (chronic '*')

NFPA CODES


	0
3		1

MANUFACTURER DISCLAIMER: The information in this MSDS was obtained from current and reputable sources. However, the data is provided without any warranty, express or implied, regarding its correctness or accuracy. It is the user's responsibility both to determine safe conditions for use of this product and to assume liability for loss, injury, damage or expense resulting from improper use of this product.